Wild-type lytic bacteriophages against Salmonella Heidelberg: Further characterization and effect of prophylactic therapy in broiler chickens.

To characterize wild-type bacteriophages and their effect on Salmonella Heidelberg intestinal colonization in broilers, phages combined in a cocktail were continuously delivered via drinking water since the first day after hatching. After challenge with a field strain, broilers were evaluated at regular intervals for S. Heidelberg and bacteriophages in tissues and cecum, and gross and microscopic lesions in organs. Phages were highly virulent against S. Heidelberg by efficiency of plating. One-step growth curves exhibited eclipse period from 20 to 25 min, whereas the lowest latent period and higher burst size found were 45 min and 54 PFU/cell, respectively. Bacteriophage whole genomic sequencing analyses revealed a lack of genes related to lysogeny, antimicrobial resistance, and virulence factors. Relevant gross or microscopic lesions were absent in tissues analyzed from treated broilers. Although numerically stable bacteriophage concentrations were detected in the cecal contents of treated broilers, no significant difference was found for the S. Heidelberg cecal load in comparison to the untreated group and for the prevalence of positive tissues throughout the evaluated period. The phages produced turbid plaques against some S. Heidelberg re-isolated from treated broilers, suggesting the evolving of a resistant subpopulation. Overall, the results provide new evidence of the safety and in vitro replication of such phages in S. Heidelberg. Nevertheless, continuous administration of the phage suspension most likely induced the development of bacteriophage-resistant mutants, which might have affected the in vivo effect. Therefore, a putative administration protocol should be based on other strategies, such as short-term therapy at pre-harvest age.

Mycoplasma hyopneumoniae infection dynamics in naïve replacement gilts introduced to positive farms.

This study was designed to characterize the dynamics of infection of Mycoplasma hyopneumoniae in naïve replacement gilts after introduction to positive systems. Ninety-eight naïve gilts were monitored in three positive commercial farms (A, B, and C). The näive gilts were housed for 21 days in pens adjacently located to older gilt cohorts (named seeders), which have been naturally exposed to the positive farms. The infection dynamics was evaluated by PCR and ELISA, from laryngeal swabs and serum samples, respectively. Samples were collected at 150 (arrival), 165, 180, 210, 240, 270, 300 days of age (doa), and pre-farrowing. Infection occurred rapidly on farms A and B, taking 25.2 and 23.9 days for 95% of gilts to be PCR positive, respectively. There was no influence on the number of seeders at the time of exposure, but their absence (farm C) could explain the extended period it took for gilts to get infected (69.4 days). On average, it took 162.2 days after the first PCR detection for 85% of gilts to stop shedding the bacterium. The serology results were consistent with the herd infection curve. At pre-farrowing, 100% of gilts seroconverted and 36.7% remained PCR positive. A total of 1.33% of piglets were positive at weaning. Fifteen variants were detected among the three farms by MLVA. The acclimation protocol was efficient and easy to perform, and the presence of seeders was likely critical for early acclimation for M. hyopneumoniae.

A polyvalent virosomal influenza vaccine induces broad cellular and humoral immunity in pigs.

BACKGROUND: Influenza A virus (IAV) is endemic in pigs globally and co-circulation of genetically and antigenically diverse virus lineages of subtypes H1N1, H1N2 and H3N2 is a challenge for the development of effective vaccines. Virosomes are virus-like particles that mimic virus infection and have proven to be a successful vaccine platform against several animal and human viruses. METHODS: This study evaluated the immunogenicity of a virosome-based influenza vaccine containing the surface glycoproteins of H1N1 pandemic, H1N2 and H3N2 in pigs. RESULTS: A robust humoral and cellular immune response was induced against the three IAV subtypes in pigs after two vaccine doses. The influenza virosome vaccine elicited hemagglutinin-specific antibodies and virus-neutralizing activity. Furthermore, it induced a significant maturation of macrophages, and proliferation of B lymphocytes, effector and central memory CD4+ and CD8+ T cells, and CD8+ T lymphocytes producing interferon-γ. Also, the vaccine demonstrated potential to confer long-lasting immunity until the market age of pigs and proved to be safe and non-cytotoxic to pigs. CONCLUSIONS: This virosome platform allows flexibility to adjust the vaccine content to reflect the diversity of circulating IAVs in swine in Brazil. The vaccination of pigs may reduce the impact of the disease on swine production and the risk of swine-to-human transmission.

Microbiological Quality of Pig Carcasses in a Slaughterhouse under Risk-Based Inspection System.

Meat product inspection is one of the procedures adopted more than a century ago to guarantee food quality and safety for consumption. Due to technology and regulation advancement for farming and slaughtering pigs, a change in zoonotic profile attributed to pork has been identified. Thus, a global movement began to establish inspection parameters based on epidemiological risk profiles, culminating in the publication of a new regulation in Brazil in 2018. This normative instruction establishes that slaughterhouses under federal inspection must implement risk-based inspection until 2028. Changes in the inspection system can generate questions and objections on the part of customers and consumer markets. In order to assess microbiological contamination when adopting a risk-based inspection system, the occurrence of Salmonella spp. and the quantification of Enterobacteriaceae and mesophilic aerobic counts were compared in pig carcasses slaughtered under traditional and risk-based inspection systems. A statistical significance reduction was identified regarding the quantification of Enterobacteriaceae (log -0.18 to -1.61 CFU/cm2) and mesophilic aerobic counts (log 4.60 to 3.49 CFU/cm2). The occurrence of Salmonella spp. did not show a significant difference (4% to 5.3%). The results allowed us to conclude that adopting risk-based inspection systems improves food safety through Enterobacteriaceae and mesophilic aerobic counts reduction.

Nicarbazin Residue in Tissues from Broilers Reared on Reused Litter Conditions.

Nicarbazin (NCZ) is a worldwide used anticoccidial in poultry farming to avoid coccidiosis disease when chickens are reared on conventional poultry litter. If proper dosage and withdrawal time are not followed, the component dinitrocarbanilide (DNC) of NCZ may be present in chicken tissues, therefore posing a risk to consumers if the residues are above 200 µg/kg. Litter reuse is a common and important practice in commercial chicken production. Literature is lacking about the influence of litter reuse on DNC deposition in chicken tissues and its impact on food safety. We aimed to evaluate DNC residues in breast and liver by LC-MS/MS from broilers from an experiment with 10 consecutive flocks during 2 years. The experiment included three treatments containing NCZ in the diet (T1 = 125 mg/kg, 1−21 d; T2 = 125 mg/kg, 1−32 d; T3 = 40 mg/kg, 1−32 d). DNC residues in chicken breast at 21 d in T1 ranged from 648.8−926 µg/kg, at 32 d in T2 and T3 varied, respectively, from 232−667 µg/kg and 52−189 µg/kg. Regarding liver, DNC residues at 21 days in T1 ranged from 11,754−15,281 µg/kg, at 32 days in T2 and T3 varied, respectively, from 10,168−15,021 µg/kg and 2899−4573 µg/kg. When NCZ was withdrawn from feed, DNC residues dropped to

On the influence of the source of porcine colostrum in the development of early immune ontogeny in piglets.

The effects on the ontogeny of serum cytokines and immune cells caused by feeding suckling piglets with sow/gilt colostrum and milk replacer was assessed in the present study. After farrowing, the piglets born were randomized into six groups: GG and SS (n = 10/group): piglets were kept with their dam; GS (n = 10): piglets were changed from gilts to sows; SG (n = 10): piglets were changed from sows to gilts; GMR (n = 6) and SMR (n = 8): piglets from either gilts or sows were isolated from the dams and were bottle-fed ad libitum with commercial formula milk replacer. The piglets remained in the groups during the first 24 h of life and were later returned to their respective mothers. Serum immunoglobulin concentration and lymphocyte proliferation from the blood, spleen, thymus, and mesenteric lymph node of the piglets were assessed at 24 h and at 28 days of age. Serum cytokine concentrations were measured through a cytokine multiplex assay at 24 h. Overall, piglets suckling on sows (SS and GS) had a higher concentration of serum immunoglobulin at 24 h, which was also associated with a rise in plasma cytokine concentration and greater ability of B and T cells from lymphatic organs and blood mononuclear cells to respond to mitogens. We suggest a bias towards Th1-, Th2-, and Th17-cell polarizing and cytokines during the suckling period, which may be influenced by maternal immunological factors in the colostrum, such as dam parity. All findings suggest sow parity having a possible role, which may contribute to exerting a modulating action on immune response development.

Effect of gaseous ozone application during chilling on microbial and quality attributes of pig carcasses.

Ozone application has been suggested as an additional measure to the slaughter animals under hygiene programs. In this study, we determined the efficacy of gaseous ozone applied to pig carcasses during chilling (16 h at 2-5°C). Forty carcasses were allocated to each treatment: control, without ozone application (T1) and 5 ppm gaseous ozone application (T2), divided in two 4-h periods. The carcasses were sampled before and after chilling. The average counts of total aerobic mesophilic (TAM) bacteria before chilling were not different (p = 0.55) between T1 and T2. In turn, after chilling, the ozone-treated carcasses had significantly reduced about 0.4 colony-forming units (CFU)/cm2 of TAM counts (p < 0.001) than the control carcasses. No significant reduction was observed in the number of carcasses positive for Listeria sp. and Escherichia coli after gaseous ozone treatment; while a tendency (p = 0.08) of lower number of Salmonella positive carcasses in T2 was observed. Common macrorestriction (pulsed-field gel electrophoresis) patterns of S. enterica were observed in the carcasses before and after chilling. Pork samples from treated and untreated carcasses with ozone showed no lipid oxidation or altered color and pH. The results indicate that the gaseous ozone in the tested protocol is effective in reducing TAM populations, but not effective in decreasing the number of carcasses positive for E. coli and Listeria sp. Regarding Salmonella, the tendency of positive carcasses reduction may encourage further studies by testing other protocols of gaseous ozone application inside the chilling chamber.

Health profile of free-range wild boar (Sus scrofa) subpopulations hunted in Santa Catarina State, Brazil.

Wild boars represent a potential dissemination source of important pathogens to public and animal health, since they can host several pathogens. This study aimed to evaluate the health profile of wild boars hunted for population control in the state of Santa Catarina (SC), south of Brazil. For this study, tissue and blood samples were collected from 61 wild boars hunted from October 2017 to November 2018. All 61 serum samples were screened for antibodies by different assays, presenting the following seroprevalence: 52.4% for porcine circovirus type 2 (PCV2); 21.3% for Leptospira spp.; 19.7% for Mycoplasma hyopneumoniae; 13.1% for hepatitis E virus (HEV); and 9.8% for influenza A virus (IAV). No seroreaction was observed for Brucella spp. and classical swine fever virus (CSFV). At necropsy, the main lesions observed were evidence of pulmonary metastrongylid parasites, haemorrhagic lymph nodes and white-spotted liver. Histopathological analyses mainly showed interstitial pneumonia, bronchopneumonia and bronchi-associated lymphoid tissue (BALT) hyperplasia. There was a significant association between metastrongylid parasitism and BALT hyperplasia in lungs. Pathological findings of wild boars indicate that the assessed individuals were not exposed to notifiable diseases, such as CSFV, African swine fever virus and foot-and-mouth disease, which cause economic damage by non-tariff trade barriers. However, the detection of antibodies against PCV2 and M. hyopneumoniae, pathogens that impact commercial production, indicates the circulation of these agents, with frequency variation in wild populations. This shows the potential risk of pathogen transmission among domestic swine populations and free-living ones. The detection of antibodies against zoonotic agents such as HEV, IAV and Leptospira spp., other than characterizing the pathogens' circulation in these populations, suggests a potential risk to public health and pig farming, depending on the interactions established with the environment, humans and domestic swine.

A new kinetic model to predict substrate inhibition and better efficiency in an airlift reactor on deammonification process.

A collection of kinetic models to explore the bacteria pathway inhibition by high-ammonia during deammonification process was fitted. The main goal was to determine the substrate concentration to operate the deammonification with efficiency, performance and low impact to ANAMMOX and ammonia-oxidizing bacteria (AOB) by substrate. A new mathematical model was created to describe the deammonification behavior, since the empirical theoretical models showed inconsistent parameters to describe the process. The proposed model showed significant prediction to the estimable parameters and according to it, until 550 mg NH3-N L-1 no inhibitions by ammonia and nitrite were observed. However, concentrations higher than this promote the decrease on specific bacterial activity and nitrite accumulation, since it was not quickly consumed by the bacteria. The proposed model can be applied to predict microorganism affinity and inhibition by substrate over a wide range of ammonia concentrations (<900 mgNH3-N L-1) in reactors treating high-ammonia concentration swine wastewater.

Wooden breast and white striping: comparative occurrence in three poultry companies

ABSTRACT: To increase the amount of meat produced, researchers have promoted intensive genetic selection for growth rate and muscling and have improved nutrition and management conditions. However, there has been an increase in the number of reports of breast muscle myopathies observed in poultry processing plants, including white striping (WS) and wooden breast (WB). This study aimed to evaluate and to compare the occurrence of WS and WB myopathies in three poultry processing plants and to perform an anatomopathological characterization, including macroscopic and microscopic analyses. A total of 408,334 carcasses were condemned or downgraded due to the presence of WB or WS, which represents 0.73% of the total number of slaughtered animals during the evaluated period. WB was more frequent than WS, but the occurrence of each myopathy varied significantly according to each establishment. WB was more frequent in the establishment which includes only male flocks, an average age of 45 days, and an average live weight of 2775g (B). WS was more frequent in establishment with male, female and mixed flocks, average ages ranging from 41 to 44 days, and average live weight 1731g-2830g (A). It is probably related with specific condition of each poultry company, including genetics, age, nutrition and management conditions. Macroscopically, WB and WS lesions are characterized by hypertrophy and stiffness of the pectoralis major muscle. Under microscopy, the myopathies showed similarities regarding the detected histological abnormalities, characterized by a process of myodegeneration, although the connective tissue infiltrate was more severe in the breasts with WB than in those with WS myopathy. The results found in this study demonstrate that the rates of condemnation for these myopathies are high, vary significantly among the analyzed companies and may cause major economic losses for the productive sector in the region.

RESUMO: Para melhorar a quantidade de carne produzida, os pesquisadores têm promovido ao longo dos anos uma seleção genética intensiva para a taxa de crescimento e desenvolvimento de músculos, além de melhorias nas condições nutricionais, sanitárias e de manejo. No entanto, houve um aumento no número de relatos de miopatias dos músculos do peito observados em abatedouros-frigoríficos de aves, incluindo white striping (WS) e wooden breast (WB). O objetivo deste estudo foi avaliar a ocorrência de WB e WS em três abatedouros-frigoríficos de aves e realizar uma caracterização anatomopatológica, incluindo análises macroscópicas e microscópicas. Um total de 408.334 carcaças foi condenado (total ou parcialmente) devido à presença WB ou WS, o que representou 0,73% do número total de animais abatidos durante o período avaliado. Apesar de a ocorrência de WB ter sido maior do que a de WS, a frequência de cada uma variou significativamente de acordo com o estabelecimento. WB foi mais frequente no estabelecimento que incluía apenas lotes de machos, com média de 45 dias de idade e peso médio ao abate de 2775g (B). WS foi mais frequente no estabelecimento com lotes de machos, fêmeas e mistos, com idade entre 41 e 44 dias e peso médio ao abate entre 1731g-2830g (A). Isto pode ser justificado por condições específicas de cada empresa, incluindo genética, idade das aves, nutrição e condições de manejo. Macroscopicamente, as lesões de WB e de WS foram caracterizadas principalmente por hipertrofia e rigidez do músculo pectoralis major. À microscopia, ambas as miopatias mostraram semelhanças em relação às anormalidades histológicas detectadas, caracterizadas principalmente por um processo de miodegeneração. Nos músculos apresentando WB, o infiltrado de tecido conjuntivo foi mais intenso quando comparado àqueles com WS. Os resultados encontrados neste trabalho demonstram que os índices de condenação por essas miopatias são altos, variam significativamente entre as empresas analisadas e podem causar grandes perdas econômicas para o setor produtivo da região.

Wooden breast and white striping: comparative occurrence in three poultry companies / Wooden breast e white striping: ocorrência em três empresas avícolas

To increase the amount of meat produced, researchers have promoted intensive genetic selection for growth rate and muscling and have improved nutrition and management conditions. However, there has been an increase in the number of reports of breast muscle myopathies observed in poultry processing plants, including white striping (WS) and wooden breast (WB). This study aimed to evaluate and to compare the occurrence of WS and WB myopathies in three poultry processing plants and to perform an anatomopathological characterization, including macroscopic and microscopic analyses. A total of 408,334 carcasses were condemned or downgraded due to the presence of WB or WS, which represents 0.73% of the total number of slaughtered animals during the evaluated period. WB was more frequent than WS, but the occurrence of each myopathy varied significantly according to each establishment. WB was more frequent in the establishment which includes only male flocks, an average age of 45 days, and an average live weight of 2775g (B). WS was more frequent in establishment with male, female and mixed flocks, average ages ranging from 41 to 44 days, and average live weight 1731g-2830g (A). It is probably related with specific condition of each poultry company, including genetics, age, nutrition and management conditions. Macroscopically, WB and WS lesions are characterized by hypertrophy and stiffness of the pectoralis major muscle. Under microscopy, the myopathies showed similarities regarding the detected histological abnormalities, characterized by a process of myodegeneration, although the connective tissue infiltrate was more severe in the breasts with WB than in those with WS myopathy. The results found in this study demonstrate that the rates of condemnation for these myopathies are high, vary significantly among the analyzed companies and may cause major economic losses for the productive sector in the region.(AU)

Para melhorar a quantidade de carne produzida, os pesquisadores têm promovido ao longo dos anos uma seleção genética intensiva para a taxa de crescimento e desenvolvimento de músculos, além de melhorias nas condições nutricionais, sanitárias e de manejo. No entanto, houve um aumento no número de relatos de miopatias dos músculos do peito observados em abatedouros-frigoríficos de aves, incluindo white striping (WS) e wooden breast (WB). O objetivo deste estudo foi avaliar a ocorrência de WB e WS em três abatedouros-frigoríficos de aves e realizar uma caracterização anatomopatológica, incluindo análises macroscópicas e microscópicas. Um total de 408.334 carcaças foi condenado (total ou parcialmente) devido à presença WB ou WS, o que representou 0,73% do número total de animais abatidos durante o período avaliado. Apesar de a ocorrência de WB ter sido maior do que a de WS, a frequência de cada uma variou significativamente de acordo com o estabelecimento. WB foi mais frequente no estabelecimento que incluía apenas lotes de machos, com média de 45 dias de idade e peso médio ao abate de 2775g (B). WS foi mais frequente no estabelecimento com lotes de machos, fêmeas e mistos, com idade entre 41 e 44 dias e peso médio ao abate entre 1731g-2830g (A). Isto pode ser justificado por condições específicas de cada empresa, incluindo genética, idade das aves, nutrição e condições de manejo. Macroscopicamente, as lesões de WB e de WS foram caracterizadas principalmente por hipertrofia e rigidez do músculo pectoralis major. À microscopia, ambas as miopatias mostraram semelhanças em relação às anormalidades histológicas detectadas, caracterizadas principalmente por um processo de miodegeneração. Nos músculos apresentando WB, o infiltrado de tecido conjuntivo foi mais intenso quando comparado àqueles com WS. Os resultados encontrados neste trabalho demonstram que os índices de condenação por essas miopatias são altos, variam significativamente entre as empresas analisadas e podem causar grandes perdas econômicas para o setor produtivo da região.(AU)

Survey of Campylobacter in foods implicated in foodborne diseases in Southern Brazil.

Campylobacter is not routinely tested in foodborne disease investigations in Brazil. Here, we studied the occurrence of Campylobacter among other food-related bacteria commonly found in foodborne disease outbreaks reported in Rio Grande do Sul State, Southern Brazil. Seventy-two food samples were analyzed by using culture-based detection methods during the 18-month investigation of 36 foodborne disease outbreaks. The sampled foods from the foodborne disease outbreaks were all negative for Campylobacter . However, at least one of other routinely investigated foodborne-related bacteria was detected in 29.17% (21/72) of the samples. Taken together, these results suggest the need to monitor Campylobacter in foodborne diseases to detect sporadic cases caused by Campylobacter that might go unnoticed in Rio Grande do Sul.

Investigation of Listeria monocytogenes, Salmonella enterica and Yersinia enterocolitica in pig carcasses in Southern Brazil / Pesquisa de Listeria monocytogenes, Salmonella enterica and Yersinia enterocolitica em carcaças de suínos no sul do Brasil

The intensification of pig production and advances in the sanitary control of herds profoundly changed the profile of risk attributed to pork consumption. In the actual scenario, most microorganisms related to macroscopic lesions observed in the post mortem inspection are not transmitted by food, while foodborne bacteria of importance to consumer health do not cause macroscopic lesions. In Brazil, the "Ministério da Agricultura, Pecuária e Abastecimento" requested a scientific opinion on the prioritizing of pathogens potentially transmitted by unprocessed pork. After conducting a qualitative risk assessment, only Salmonella enterica was classified as of high risk to consumers. The present study was part of the validation step of the risk assessment and aimed to investigate the frequency of S. enterica, Yersinia enterocolitica and Listeria monocytogenes and hygienic-sanitary indicators in pig carcasses of pigs rose under intensive production and slaughtered under the Federal Inspection System in three slaughterhouses located in Southern Brazil. Additionally, the antimicrobial resistance profile of the isolated pathogens was also investigated. A total of 378 carcasses were sampled by superficial sponges before the chilling step in three slaughterhouses. Samples were investigated for the presence of the three aforementioned pathogens and subjected to enumeration of Colony Formation Units (log CFU.cm-1) of total aerobic mesophiles (TAM) and Enterobacteriaceae. Salmonella strains were tested by disc diffusion test for resistance to eleven antimicrobials. There were significantly statistical differences (p<0.0001) on the median counts of both indicators between the slaughterhouses. The median of TAM was very close for Slaughterhouses A and B: 1.573 log CFU.cm-1 and 1.6014 log CFU.cm-1, respectively. While in Slaughterhouse C, a higher TAM median was detected (2.216 log CFU.cm-1). A similar profile was observed regarding to Enterobacteriaceae, and medians were calculated as follow: -0.426 log CFU.cm-1 in Slaughterhouse A; 0.2163 log CFU.cm-1 in B; and 0.633 log CFU.cm-1 in C. Regarding the pathogens investigated, L. monocytogenes was not detected and only one carcass from Slaughterhouse C was positive for Y. enterocolitica. Thus, the results suggest a very low prevalence of L. monocytogenes and Y. enterocolitica in the sampled population. A total of 65 (17.2%) carcasses were positive for S. enterica, with a difference in frequencies between slaughterhouses and slaughter days. The prevalence of Salmonella positive carcasses was higher in the Slaughterhouse C (25.4%; CI 95% 19-32%) in comparison with A (9.5%; CI 95% 9-14%) and B (18.3%; CI 95% 12-24%). There was no significantly statistical association between Enterobacteriaceae counts and Salmonella isolation on carcass surface (p=0.69). The slaughtering day, nested within the slaughterhouse, explains 31.3% of Salmonella prevalence variability. S. Typhimurium (38.1%) was the most prevalent, followed by S. Infantis (30.1%). Among the 61 Salmonella strains tested for resistance to antimicrobials, 18 (31.6%) were full-susceptible. No strain displayed resistance to azithromycin, ceftazidime, cefotaxime and meropenem. The highest resistance frequency was displayed to tetracycline (54.1%), followed by ampicillin (50.82%), nalidixic acid (42.62%) and chloramphenicol (42.62). Multi-resistance was detected in 52.54% of the, strains. In conclusion, S. enterica is more prevalent in pre-chill pig carcasses than Y. enterocolitica and L. monocytogenes and thus should be prioritized in monitoring and control programs at slaughter. Salmonella serovars varied among slaughterhouses and present significant differences in their resistance to antimicrobials. Slaughterhouses that present higher medians of TAM or Enterobacteriaceae in a monitoring period may have higher S. enterica prevalences as well. However, there is a high variation of S. enterica prevalence among slaughter days, which cannot be always related to the hygienic indicators counts observed on a given day.(AU)

A intensificação da produção de suínos e os avanços no controle sanitário dos rebanhos alterou de forma importante o perfil de risco do consumo de carne suína. No cenário atual, a maioria dos microrganismos causadores de lesões macroscópicas detectáveis na inspeção post mortem não são transmissíveis por alimentos, enquanto bactérias de importância como causadoras de doenças transmitidas por alimentos não causam lesões macroscópicas. No Brasil, o Ministério da Agricultura, Pecuária e Abastecimento solicitou uma opinião científica sobre a priorização de patógenos potencialmente transmitidos pela carne suína in natura. Após conduzir uma avaliação de risco qualitativa, apenas Salmonella enterica foi classificada como de alto risco para o consumidor. O presente estudo foi parte da etapa de validação da avaliação de risco e objetivou: investigar a frequência de S. enterica, Yersinia enterocolitica e Listeria. monocytogenes; e enumerar indicadores higiênico-sanitários em carcaças de suínos abatidos sob inspeção federal em frigoríficos dedicados ao abate de suínos sob sistema intensivo de criação no sul do Brasil. Além disso, o perfil de resistência a antimicrobianos dos patógenos isolados foi investigado. A superfície de um total de 378 carcaças foi amostrada por esponjas, na etapa de pré-resfriamento em três matadouros frigoríficos (A, B, C). As amostras foram investigadas quanto à presença dos três patógenos acima mencionados e quanto à enumeração de Unidades Formadoras de Colônia (log UFC.cm-1) de mesófilos aeróbios totais (MAT) e Enterobacteriaceae. As cepas isoladas de Salmonella foram testadas quanto à resistência a onze antimicrobianos pela técnica de disco difusão. As medianas de contagem de ambos os indicadores apresentaram diferença significativa (p<0,0001) entre matadouros-frigoríficos. A mediana de MAT foi bastante próxima para A e B (1,573 log UFC.cm-1 e 1,6014 log UFC.cm-1, respectivamente), enquanto em C uma mediana de MAT mais elevada foi determinada (2,216 log CFU.cm-1). Um perfil semelhante foi observado em relação a Enterobacteriaceae, sendo as medianas calculadas para A, B e C, respectivamente: -0,426 log CFU.cm-1; 0,2163 log UFC.cm-1; e 0,633 log UFC.cm-1. Em relação aos patógenos investigados, L. monocytogenes não foi detectada e apenas uma carcaça, do Matadouro C, foi positiva para Y. enterocolitica. Portanto, os resultados sugerem uma prevalência muito baixa desses patógenos na população amostrada. Em um total de 65 (17,2%) carcaças houve isolamento de S. enterica, com diferença nas frequências observadas entre matadouros e dias de abate. A prevalência de carcaças positivas para S. enterica foi maior no Matadouro C (25,4%; IC95% 19-32%) em comparação com A (9,5%; IC95% 9-14%) e B (18,3%; IC95% 12-24%). Não houve associação estatística entre o número de Enterobacteriaceae e o isolamento de S. enterica na superfície das carcaças (p=0,69). O dia de abate agrupado por frigorífico explica 31,3% da variação na prevalência de Salmonella. O sorovar mais frequente de S. enterica foi Typhimurium (38,1%) seguido de S. Infantis (30,1%). Entre as 61 cepas de S. enterica testadas quanto à resistência a antimicrobianos, 18 (31,6%) foram totalmente suscetíveis aos antimicrobianos testados. Nenhuma cepa apresentou resistência a azitromicina, ceftazidima, cefotaxima e meropenem. As maiores frequências de resistência foram demonstradas contra tetraciclina (54,1%), ampicilina (50,8%), ácido nalidíxico (42,62%) e cloranfenicol (42,62%). Em 52,54% das cepas foi detectada multi-resistência. Em conclusão, S. enterica é mais prevalente em carcaças suínas no pré-resfriamento do que Y. enterocolitica e L. monocytogenes. Portanto, S. enterica deve ser priorizada em programas de monitoramento e controle ao abate. Os sorovares de Salmonella variam entre matadouros e apresentam diferenças significativas na resistência a antimicrobianos. Matadouros de suínos que apresentam medianas de MAT e Enterobacteriaceae num período de monitoramento podem apresentar também prevalências mais de altas de presença de S. enterica. Entretanto, há uma alta variabilidade na frequência de S. enterica entre dias de abate, e nem sempre há relação entre essa frequência e a contagem de indicadores higiênico-sanitários determinados num determinado dia.(AU)

Evaluation of physical euthanasia for neonatal piglets on-farm.

Twenty-seven neonate piglets (range from 0.35 to 1.17 kg) were evaluated for the effectiveness of blunt force trauma as a method of on-farm cull. Brainstem function, brain injury, and hemorrhage scores (increasing from 0 to 3) were assessed after striking the head against a concrete floor. Electroencephalograms (EEG) from a subset of 15 piglets were recorded before and after blunt force trauma for electrophysiological assessments. Blunt force trauma was performed by a single experienced farmer in a commercial farm by holding the piglet by its both hind legs and striking the head against the concrete floor. All piglets remained recumbent and did not show brainstem reflexes. Only one piglet did not presented tonic/clonic physical activity. The mean time to the onset of persistent isoelectric EEG was 64.3 ± 7.3 s (range 18 to 115). Total power, theta, alpha, and beta power decreased to approximately 45%, 30%, 20%, and 15% from pretreatment power, respectively, by 15-s post-impact. There were no periods of normal-like EEG after the culling. Bruises in the neck and shoulder were found in 67% and 70% of piglets, respectively. All piglets presented skull fractures with 20% having the nasal bone(s) fractured. Brain damage was found in all piglets, mainly in the frontal lobe(s). The occipital lobe(s) presented the greatest frequency of severe damage. The analysis of the radiographs also found a high frequency of fractures in this region. Hemorrhage was most frequent in the frontal, parietal, occipital lobes, and midbrain. When performed correctly with the appropriate weight class, blunt force trauma can be used as an effective method for the on-farm killing of nursing piglets resulting in death. However, this method should not be promoted over more reliable and repeatable cull methods such as captive bolt gun. As with blunt force trauma, there is a significant potential for animal welfare harm associated with inappropriate practice, lack of accuracy, issues with repeatability, and operator fatigue.

Detecting Infectious Bursal Disease Using a VP1 Gene-Based RT-qPCR Assay Compared to Standard Methods of Virus Isolation, ELISA, and Histopathology.

Infectious bursal disease (IBD) is an immunosuppressive viral disease of chickens, associated with severe economic losses and major threats to poultry production worldwide. Disease prevention programs rely on unequivocal identification of the pathogen, as well as vaccination programs. This study developed a sensitive, one-step, real-time, quantitative reverse transcription polymerase chain reaction (RT-qPCR) assay using a hydrolysis probe system for infectious bursal disease virus (IBDV, VP1 gene) detection and quantification, which was compared to other routinely used diagnostic methods. The assay successfully detected IBD reference viruses and field isolates. The absence of cross-reactivity was detected with negative samples or with other avian viruses in the analytical specificity test. The detection limit of this assay was 70 RNA copies. RT-qPCR was more sensitive in the detection of serially diluted IBDV isolates compared to virus isolation. For clinical samples, the sensitivity and specificity values of RT-qPCR compared to enzyme-linked immunosorbent assay (ELISA) were 97.5% and 100%, respectively, and compared to histopathology, these values were 100% and 93.94%, respectively. RT-qPCR can provide a simple and reliable assay for IBDV surveillance programs and for evaluation of control strategies.

Effect of time of therapy with wild-type lytic bacteriophages on the reduction of Salmonella Enteritidis in broiler chickens.

Salmonella Enteritidis remains a leading cause of human foodborne disease, mostly associated with the consumption of contaminated poultry products. To more strategically implement a phage therapy scheme for S. Enteritidis control in broilers, a cocktail containing three wild-type lytic bacteriophages (LBs) previously isolated from chickens was evaluated shortly and later after a challenge. Genomic characterization, lytic spectrum and in vitro efficacy were determined for each studied LB. In independent trials, broilers challenged with S. Enteritidis on day of hatch received phage therapy from 6 to 10 days of age (early treatment), and from 31 to 35 days of age (later treatment). S. Enteritidis analyses were performed before treatment and at 1, 4, 7 and 10 days post-treatment (dpt) in both trials. Partial DNA sequence analysis of each LB revealed close similarity to the Ackermannviridae family. LBs lysed different Salmonella enterica serovars, while other tested bacteria were refractory. An in-vitro reduction of 1.49, 0.65 and 0.58 log10 CFU/mL in S. Enteritidis number was obtained after co-incubation for 3 h with each LB. Both in vivo trials showed a significant reduction in the average number of intestinal S. Enteritidis calculated after phage therapy compared with controls. However, the highest efficiency was found in the later therapy, which resulted in a reduction of 1.08 log10 CFU/g in the average from 4 to 10 dpt, showing potential for future use as a pre-harvest strategy to reduce the S. Enteritidis intestinal colonization in broilers on farms.

Alternative light colors in suckling piglet creep area: preference and validation tests in swine maternity / Cores alternativas de luz de abrigos escamoteadores para leitões lactentes: teste de preferência e validação em maternidade suína

ABSTRACT: We performed a two-stage experiment: a preference and a validation test in swine litters, to determine whether suckling piglets preferred alternative light colors in their creep area over white light; we also determined whether the preferred color affected piglet behavior. In the first stage, five trials of two consecutive days were performed, each at 21-day intervals. In each trial, 40 piglets, from three to five days old, from four F1 sows (Large White x Landrace), were distributed in four treatments, in a paired scheme, receiving the following treatments: Treatment GR: white light vs. green light ; Treatment BL: white light vs. blue light; Treatment YE: yellow light vs. white light; Treatment RD: white light vs. red light. For the validation test, three consecutive lots of eight F1 sows (Large White x Landrace) and their corresponding maternity were used, remaining from birth under the influence of treatments T_Gr and T_Wh, totaling three replicates. T_Gr corresponded to four creep areaswith green LED light and T_Wh to four nurseries with white LED light. The piglets showed a significant preference only for white over blue. Among the alternative colors, piglets significantly preferred green. In the validation stage, there was no significant effect of colors on the mean percentage of permanence of the piglets inside the creep areas over all evaluated periods. Piglets between two and five days of age prefer green lighting;however,in the creep area, the light color used did not influence piglet behavior.

RESUMO: Foi realizado um experimento de duas etapas: teste de preferência e validação em maternidade suína, para verificar se leitões possuem preferência por cores alternativas de luz do abrigo escamoteador em relação à luz branca, e o efeito da cor de luz preferida em teste realizado em abrigos escamoteadores (cor alternativa e branca) no comportamento de leitões. Na primeira, foram realizados cinco ensaios de dois dias cada, em intervalos de 21 dias. Quarenta leitões, entre três e cinco dias de vida, provenientes de quatro matrizes F1 (Large White x Landrace), foram distribuídos em quatro tratamentos, em esquema pareado: Tratamento Vd: luz branca/luz verde; Tratamento Az: luz branca/luz azul; Tratamento Am: luz amarela/luz branca; Tratamento Vm: luz branca/luz vermelha. Para a validação, três lotes consecutivos de oito matrizes F1 (Large White x Landrace) e suas leitegadas permaneceram desde o nascimento sob os tratamentos T_Vd e T_Br. T_Vd correspondia a quatro escamoteadores com luz de LED verde e T_Br a quatro escamoteadores com luz de LED branca. A comparação entre cada cor alternativa e o branco mostrou diferença quanto à preferência (p<0,05) apenas para o azul. Entre as cores alternativas os leitões preferem a cor verde (p<0,05). Na etapa de validação, não houve efeito (p>0,05) no percentual médio de permanência dos leitões no interior dos escamoteadores, entre as cores de luz, para todos os períodos avaliados. Leitões entre dois a cinco dias de vida preferem a iluminação verde, porém no ambiente de maternidade, a cor de luz utilizada não influenciou no comportamento dos leitões.

Detection of p-Nitroaniline Released from Degradation of 4,4'-Dinitrocarbanilide in Chicken Breast during Thermal Processing.

The diphenylurea 4,4'-dinitrocarbanilide (DNC) is the residue of concern left in edible tissues of broilers fed diets containing the anticoccidial nicarbazin. When chicken meat is submitted to thermal processing, p-nitroaniline (p-NA) is expected from DNC degradation. This work aimed at evaluating whether thermal processing of DNC-containing chicken meat induces p-NA appearance. First, a hydrolysis assay was performed in aqueous solutions at 100 °C in different pH, confirming that DNC cleavage yields p-NA. Then a novel LC-MS/MS method was used to detect traces of this aromatic amine in DNC-containing chicken breast fillets subjected to cooking methods. Our evidence showed p-NA occurrence in such chicken meat samples, which corroborated results from hydrolysis assay. The p-NA appearance in fillets was rather discrete during boiling treatment, but its concentration became pronounced over time for grilling, frying, and roasting, achieving respectively 326.3, 640.0, and 456.9 µg/kg. As far as we are concerned, no other research identified degradation products from DNC residue in heat-processed chicken fillets. Therefore, this study leads to additional approaches to assess impacts on food safety.

Population Dynamics of Thermotolerant Campylobacter in Broilers Reared on Reused Litter.

A study using sentinel broiler chickens was performed to address Campylobacter persistence in litter that was reused for successive flocks. Cloacal swabs, litter, drag swabs, darkling beetles, feed, and drinking water were weekly sampled and analyzed by standard microbiological procedures. Thermotolerant Campylobacter isolated strains were confirmed by polymerase chain reaction and subtyped by pulsed-field gel electrophoresis analysis. Campylobacter was not detected in samples collected immediately after downtime between broiler flocks. However, Campylobacter-positive samples were first detected at 21 d. After Campylobacter was initially isolated from the cloacal swabs, reused litter, drag swabs, or darkling beetles, these samples remained Campylobacter positive in the following weeks until the end of the rearing period. Campylobacter-positive cloacal swabs obtained from sentinel broilers ranged from 97.3% to 100% at 42 d. All isolated strains were identified as Campylobacter jejuni. Among the subtypes identified, an indistinguishable C. jejuni strain was predominant in sentinel broilers and was also detected in the other environmental samples analyzed, suggesting a common and persistent contamination source within the flocks. Sentinel broilers may have contributed to amplify the Campylobacter level, maintaining flock and broiler house contamination until the end of the production cycle.

Longitudinal study reveals persistent environmental Salmonella Heidelberg in Brazilian broiler farms.

The vast capacity for maintenance and dissemination in the environment are major challenges for the control of Salmonella spp. in poultry farms. The aim of this study was to assess environmental contamination by non-typhoidal Salmonella in successive broiler flocks in nine commercial broiler farms integrated with three companies in the south of Brazil, for a twelve-month production period. Recycled broiler litter, feed and swabs from the evaporative cooling system pads were analyzed, and the total enterobacteria count in the litter samples was ascertained. Positive broiler houses were identified in two of the three broiler companies studied, in which non-typhoidal Salmonella were detected for the first time in the first or second flock, and recurred in the recycled litter of subsequent flocks. Feed and evaporative cooling pad swab samples were also positive in at least one of the assessed flocks. The majority of the isolates (87.5%) originating from different flocks, broiler houses and companies that were sampled were identified as S. Heidelberg, with the prevalence of one single genotype. The total enterobacteria levels in the litter diminished as the flocks progressed, but the presence of Salmonella spp. was constant over the course of time, indicating that the litter management procedures were not capable of interrupting the cycle of residual contamination. The predominance of S. Heidelberg highlights its emergence and dissemination in this region, as well as its resistance and maintenance in the environment, and reinforces the need to improve prevention and recycled litter management measures.